Saabscene Saab Forum - Saab Technical Information Resource banner

Discussions Showcase Albums Media Media Comments Tags

1-18 of 65 Results
  1. Saab 9-3 Sedan/Combi/TurboX/AWD(2003+)/Conv(2004+)
    HI All, Need a little help with his one. I have been Searching forums for a while to find a how to guide for replacing the Secondary Air Injection Pump. I have lived with this fault for a while now as it as never bothered me but the new MOT Regulations mean my car will fail the MOT due to the...
  2. Classic Saab 9-3/GM900 (1994 - 2002)/Conv ( -2003)
    Hi I was just wondering, has anyone here been brave enough & successful in installing a water injection system?
  3. Classic Saab 9-3/GM900 (1994 - 2002)/Conv ( -2003)
    Hello again all not been on here for quite a while ............ Had the usual starting problems with said car , done the leak off pipes, injector seals and now replaced the pump with a second hand one but wont start now,,, is this because it needs coding to the car or is it just plain knackered????
  4. Saab 9000 (1984 - 1998)
    Ok, so after changing my igntion switch (bad), all my electronics now work. I have power to my fuel pump, all fuses are good, New CPS sensor, New DI cassette, spark present with new plugs. When i spray starting fluid in the throttle body it starts then dies immeadiately... I have pressure at the...
  5. Classic Saab 9-5 (1997 - 2009)
    Good morning, just out of curiosity (nothing wrong with my car), does anybody know exactly what type of injection system my 2004 9-5 2.3t with 185BHP got? Look it up but found different answers to the question. I would especially like to know if it is a mechanical or electronic injection...
  6. Saab 9-3 Sedan/Combi/TurboX/AWD(2003+)/Conv(2004+)
    Hi - can anybody tell me if I have any alternative to either ignoring a failed pump or paying Saab £500+ for a new one? There are some secondhand ones available on ebay so I'm wondering if there is a GM (or Volvo, BMW) equivalent but I can't find the Pierburg part no. for Saab anywhere to check...
  7. Classic Saab 900 (1979 - 1993)
    Hi, I can find a few places selling silicone cooling system hoses for TURBO classic 900 models but I can't track down anywhere selling the same for my NON TURBO 2L 16v injection, 1993 classic 900 convertible. Blue hoses would be nice :) . I can source blue silicone vacuum hoses easily enough...
  8. Classic Saab 9-5 (1997 - 2009)
    Hi all, I have read fault code P1312 from my 2000 95 Aero Hot. This appears to suggest the DI or wiring is at fault. Wiring appears OK so suspect DI. Is there a how to guide on here for changing it over. Have searched and found lots of different posts but no how to. Also where is the best...
  9. Saab Parts / Accessories, FOR SALE and WANTED
    For sale RED saab 9-3 Direct Injection pack excellent condition, tested and in full working order. Will fit other saabs 65 delivered part number 55561132.
  10. Classic Saab 9-5 (1997 - 2009)
    Assistance/advice needed please. My 54 9-5 Estate (2.2 diesel) broke down on the way to work this morning. The engine cut out and the original fault code from the recovery firm related to a sensor on the drive shaft?? The garage have replaced this earlier, however it has subsequently...
  11. Saab 9-3 Sedan/Combi/TurboX/AWD(2003+)/Conv(2004+)
    Hi. My 2003 9-3 has what appears to be a common fault with the secondary air injuction pump - its failed & expensive to fix. As the SAI system was only on for 2003 models (persumably dropped for being of no use and lots of trouble) I am looking for a way to bypass the fault and put out the...
  12. Classic Saab 9-3/GM900 (1994 - 2002)/Conv ( -2003)
    After fiddling around yesterday trying unsucesfully to fix my CEL problem I must have disturbed somethind and allowed air into the fule system. (I did notice that the head was damp around injector #4 and found the union nut was not fully tight, so I tightened it - I may have disturped the excess...
  13. Saab 9-3 Sedan/Combi/TurboX/AWD(2003+)/Conv(2004+)
    Hi Guys I am getting a P0411 secondary air injection system incorrect flow detection code on my Saab 9-3 Aero when I start from cold in the mornings. The car runs absolutely fine, even when starting from cold at lunch time. I believe it's probably the air pump, is this an easy, cheap thing to...
  14. Classic Saab 9-5 (1997 - 2009)
    Hi all, Just wondering what size and thread the bolts which hold the direct injection unit are. I was down to one (which has now disappeared)!
  15. Saab 9-3 Sedan/Combi/TurboX/AWD(2003+)/Conv(2004+)
    In the 1.9 TID engine there is a fuel cutoff when i'm releasing the accellerator pedal ?
  16. Saab Parts / Accessories, FOR SALE and WANTED
    Fully working diesel fuel pump, earlier type with single connector on top. Removed as the car failed its MOT due to chassis damage.
  17. Classic Saab 9-3/GM900 (1994 - 2002)/Conv ( -2003)
    Has anyone every refurbished a fuel injection pump? Only an electrical fault. 93 2000 w reg 2.2 TID.
  18. Classic Saab 9-5 (1997 - 2009)
    Hi All, My Engine warning light on my 9-5 3.0t this evening and I called the AA. They diagnosed a fault as described in the title above.They assurred me that it was ok to drive it home. Has anyone had this code before and, if so, what was the cause/solution? Many thanks. JesTTer
1-18 of 65 Results